Solazone Silicate Gel Batteries

 

New technology, non-polluting, top quality silicate gel batteries, with high performance, long cycle life, robust in adverse environments, and very good pricing.

SOLAZONE silicate-batteries

Based on the brand new electrolyte of liquid low sodium silicate compound, renovations have been made for cell electrode structure, material composition and battery manufacture processes.

SOLAZONE silicone batteries have successfully broken away from the shortcomings of lead-acid batteries, such as acid corrosion, acid mist pollution, low energy & power density, and short life span.

SOLAZONE silicone batteries can be successfully recycled at end of use, with the lead being reused, and the silicate used as fertiliser.

 

sibat4

 

SOLAZONE has a recognized edge over commonly used lead-acid batteries, due to its high capacity, high current output, rapid recharge times, good low temperature performance, long life span, and environmental-friendliness.

On top of that, the neutral electrolyte does not corrode the electrodes, which makes it possible to recycle the electrodes after the battery service life.

The disposed electrolyte, in the state of semi-solid grains, is a high quality fertilizer rather than a soil pollutant. The factory is rated as "Factory of Environment Friendliness" by the relevant environment protection authority for its contribution to the commitment of environmental protection.

 

sibat3

 

SOLAZONE RECHARGEABLE BATTERY FACTS:

  • Storage capacity as high as 1.75 times that of international standards;
  • They exceed the international recharge acceptance capacity standards by 2.68 times.
  • They have a high current recharge rate (0.8°C – 1.0°C);
  • They can have high current discharge, resulting in a battery that can be discharged at 30C within 8 seconds with no damage to the battery;
  • Wide working temperature range (-50°C to +70°C);
  • Long life when used under normal working conditions;
  • Low self-discharge: Full charge can be maintained for a year when stored at normal temperatures.
  • No recharge memory;
  • No acid mist emission when charging or discharging;
  • No pollution from the electrolyte;
  • The cycling charge life is as long as 10 years for the GYM Series;
  • Over 400 times of full recharging (normal acid battery is 200 times);
  • Functions normally at 6,000 meters beneath the sea;
  • Environmentally Friendly: the electrolyte can be used as fertilizer and the rest recycled;
  • Maintenance Free.

 Comparison of Solazone battery with common AGM sealed battery.

FeaturesLead-Acid BatteriesSilicone BatteriesResults
Energy/Unit Weight 29 WH/KG 45 WH/KG Higher Capacity
Charging Cycles

(Including Charging and Discharging)

280 400 Higher Charging Cycles
Degree of Sealing Sealed (with a
pressure relief valve)
Tightly Sealed Acid mist/maintenance
free and safe
Electrolyte Sulfuric Acid Silicate Compunds Pollution Free and
Environmentally Friendly
Regular Charging Time 4-8 HR 2-4 HR Shorter charging time
Rapid Charging 2-3 HR .5 HR Much shorter charging time
Internal Resistance >0.5 micro Ohm <0.05 micr Ohm 10 times less when fully charged;
20 times less when fully discharged
Self Charging Rate ≤ 15% per month ≤ 10% per 2 years Significantly lower self discharging
rate over long period of time
High current output 3-7 c 10-19 c 2.5 – 3 times better
Lowest End-point Voltage
After Discharging
1.8 V 1.2-1.8 V 0.2-0.6 V
Memory Effect from
Charging or Discharging
Memory effect at
low voltage zone
No memory effect No memory effect extends
the service life of the battery
Recovery After Discharge Relatively poor Particularly strong Results
Storage Time
Without Charging
3-6 months 1-2years Much longer storage time with minimal discharing conditions
Low Temperature Performance Output drops dramatically
below 0ºC
Functions normally
at -40ºC
Functions normally at
extreme conditions: -40ºC to + 70ºC
Highest Charging
Current Available
1.0 c 2.5 c 2.5 times higher
Service Life 2 years 5-10 years Longer service life with
lower maintenance costs

 The Silicone battery has much less memory effect and is uneffected by very cold or hot conditions, so this battery is a big improvement on the lead-acid battery. Unless the lithium-ion battery becomes much cheaper, the silicone battery is also a very good option for electric vehicles.


sibat2


Solazone Silicate Gel Battery specifications

model volts

capacity

size (mm)
weight
C10 C100 L W H
12V  7Ah 12 7 8
152 65 94 2 kg
12V 38Ah 12 38 44
174 165 196 12.8 kg
12V 100Ah 12 100 115
330 174 220 30 kg
12V 120Ah 12 120 138
407 174 210 36 kg
12V 150Ah 12 150 175
483 170 240 43 kg
12V 200Ah 12 200 230 522
240
220
61 kg
12V 250Ah 12 250 284 522 270 220 71 kg
2V 400Ah 2 300 345 211 176 330 25 kg
2V 500Ah 2 500 575 241 172 330 30 kg
2V 800Ah 2 800 920 410 175 330 49.5 kg
2V 1000Ah 2 1000  1150 475
175
330
58.5 kg
2V 1500Ah 2 1500 1725  401
351
342
91 kg
2V 2000Ah 2 2000 2300 491
351
383
117 kg

 

To Order or Contact us
Name *
Invalid Input
Email *
Please enter a valid email address
Phone Number
Invalid Input
Postcode *
Invalid Postcode
Enquiry Details
Invalid Input
  

Solazone

SOLAR STREET LIGHTS .  .  .

are made in Davao.

streetlight poless


 WE ARE PROUDLY A PHILIPPINES COMPANY

Asia solar radiation map

AND WE SERVE ALL THE PHILIPPINES MARKET